Express E145 near London on Sep 5th 2014, loss of control results in loss of 4000 feet of altitude
Last Update: July 6, 2016 / 19:46:15 GMT/Zulu time
Incident Facts
Date of incident
Sep 5, 2014
Classification
Report
Airline
Expressjet
Flight number
EV-4538
Departure
Grand Rapids, United States
Destination
Newark, United States
Aircraft Registration
N16954
Aircraft Type
Embraer ERJ-145
ICAO Type Designator
E145
On Jul 6th 2016 Canada's TSB released their final report concluding the probable causes of the serious incident were:
Findings as to causes and contributing factors
- The flight crew were aware of the weather conditions and departed, anticipating that they would be able to navigate through an extensive line of thunderstorms. However, as the flight progressed, the line of thunderstorms intensified and, as a result, the flight crew's intended route became obstructed.
- The flight crew operated the aircraft through a mature thunderstorm and, as a result, an aircraft upset and loss of control occurred.
- During the loss of control, the flight crew momentarily applied flight control inputs that exacerbated the roll attitude of the aircraft. As a result, altitude loss and recovery time were increased.
Findings as to risk
- If flight crews operate aircraft outside of manufacturer recommendations, the risk of encountering an adverse consequence is increased.
- If aircraft are operated outside of manufacturer limitations, there is a risk of compromising flight safety, resulting in injury to the occupants or damage to the aircraft.
- If cockpit voice recordings are not available to an investigation, the identification and communication of safety deficiencies to advance transportation safety may be precluded.
The TSB reported that during the upset as result of the turbulence encounter the aircraft encountered vertical accelerations between +0.20G and +2.01G were encountered, the aircraft reached a turn rate of 200 degrees per minute (3.3 degrees per second) changing the aircraft heading from 180 to 240 degrees magnetic and a peak rate of descent of 9300 fpm occurred.
The captain (10,000 hours total, 7,000 hours on type) was pilot flying, the first officer (3,400 hours total, 2,200 hours on type) was pilot monitoring. The crew had received weather information from their dispatch within their preflight briefing. The TSB reported: "A complete weather assessment provided by Environment Canada after the occurrence indicated that the weather at the time of the occurrence was generally as forecasted."
The TSB analysed that the investigation did not find any evidence of a system malfunction or failure throughout the event.
The TSB analysed:
The National Oceanic and Atmospheric Administration (NOAA) radar weather depiction reviewed by the TSB indicated that, at the time of departure, there were gaps in the line of thunderstorms. However, the size and intensity of thunderstorms can change rapidly as they mature or dissipate.
After departure, the flight crew attempted to navigate through an extensive line of thunderstorms. However, as the flight progressed, the line of thunderstorms intensified and, as a result, the flight crew's intended route became obstructed.
As the aircraft continued eastward, the flight crew could not locate an opening that would enable them to continue flying toward their destination. The crew therefore requested assistance from a company dispatcher to help them find a route through the line of thunderstorms.
The dispatcher provided an opinion on which route to take, based on what he observed on his display and his assessment of the weather. According to his display (Figure 2), the route was feasible, given the aircraft position and the location of the adverse weather.
However, shortly after turning in the direction suggested by the dispatcher, the aircraft encountered severe turbulence and experienced a loss of control, suggesting that the thunderstorm was more severe at that location than had been indicated by the dispatcher's display.
After the occurrence, the dispatcher's display (Figure 2) was compared with the NOAA radar weather depiction. In the NOAA depiction (Figure 3), the thunderstorm was shown as larger and more contiguous than on the dispatcher's display. The difference in the 2 depictions was due in part to radar reflectivity types. The dispatcher's display is a base reflectivity product, which uses the lowest reflectivity angle, while the NOAA display shows a composite radar return, which uses the maximum reflectivity from all of the multiple elevation angles.
Therefore, the NOAA depiction that showed the weather as more intense was not representative of what the dispatcher was seeing at the time of the flight crew's request for assistance. The dispatcher made a decision based on the flight-following software, which is designed for proactive weather monitoring and flight following. When it is used proactively, a flight can be rerouted before encountering adverse weather, such as a line of thunderstorms. The entire storm area can be avoided by a wide margin.
In this occurrence, when the flight crew requested assistance from dispatch, the aircraft was already positioned in the line of thunderstorms, and the flight crew were navigating between individual storm cells. As a result, the flight-following software was not used as intended (i.e., as a proactive tool to avoid weather), but rather as a reactive response to a thunderstorm encounter. Had the flight crew requested dispatch assistance earlier, a suggestion to help them avoid the weather system completely may have been provided.
The TSB analysed: "During the initial stage of the loss of control, the aircraft exceeded the maximum operating altitude. During the rapid descent, the speed increased, and the maximum operating Mach number (MMO) was exceeded. Both exceedances were above the aircraft limitations. Although these limitations were exceeded unintentionally, if aircraft are operated outside of manufacturer limitations, there is a risk of compromising flight safety, resulting in injury to the occupants or damage to the aircraft."
The software being used by the operator permits real time weather monitoring and flight following allowing the aircraft operator to proactively avoid weather. The TSB wrote: "Through use of those functions, a line of thunderstorms, such as that facing this flight crew, can be avoided, and the aircraft can be rerouted before coming within proximity of the storm."
The aircraft was equipped with a Honeywell Primus 660 weather radar. The TSB wrote: "The weather radar has several features, such as range, tilt (manual control of the antenna angle), and gain (how much of the energy leaving the antenna is focused in a particular direction), which must be used correctly during operation. If these tools are improperly managed, weather targets can be missed or underestimated. As the FDR does not record parameters from the weather radar unit, it could not be determined with certainty which settings the flight crew were using on the on-board weather radar unit. It also could not be determined how the flight crew were using the weather radar. There were no data to suggest that the weather radar was faulty."
The TSB complained that although flight data and cockpit voice recorders were installed, they were not protected following the occurrence. The occurrence was reported to the TSB only 24 hours after the occurrence at which time the cockpit voice recorder had already been overwritten. The flight data recorder contained 26 hours of flight and the last 17 flights of the aircraft.
Incident Facts
Date of incident
Sep 5, 2014
Classification
Report
Airline
Expressjet
Flight number
EV-4538
Departure
Grand Rapids, United States
Destination
Newark, United States
Aircraft Registration
N16954
Aircraft Type
Embraer ERJ-145
ICAO Type Designator
E145
This article is published under license from Avherald.com. © of text by Avherald.com.
Article source
You can read 2 more free articles without a subscription.
Subscribe now and continue reading without any limits!
Read unlimited articles and receive our daily update briefing. Gain better insights into what is happening in commercial aviation safety.
Send tip
Support AeroInside by sending a small tip amount.
Related articles
Expressjet E145 near London on Sep 5th 2014, altitude deviation of -3300/+600 feet due to extreme turbulence
An Expressjet Embraer ERJ-145 on behalf of United, registration N16954 performing flight EV-4538/UA-4538 from Grand Rapids,MI to Newark,NJ (USA), was…
Expressjet E145 at Montreal on Jun 16th 2019, fuel leak
An Expressjet Embraer ERJ-145 on behalf of United, registration N12167 performing flight EV-4074/UA-4074 from Montreal,QC (Canada) to Chicago…
Expressjet CRJ2 near Dallas on Apr 4th 2019, overheating cockpit displays
An Expressjet Canadair CRJ-200 on behalf of United, registration N909EV performing flight UA-4390 from Knoxville,TN to Houston Intercontinental,TX…
Expressjet CRJ2 at Lexington on Feb 27th 2019, bird strike
An Expressjet Canadair CRJ-200 on behalf of United, registration N884AS performing flight UA-4182 from Chicago O'Hare,IL to Lexington,KY (USA), was…
Expressjet E145 at Houston on Dec 7th 2018, runway excursion on landing
An Expressjet Embraer ERJ-145 on behalf of United, registration N16976 performing flight EV-4446/UA-4446 from Jacksonville,FL to Houston…
Expressjet E145 near Rochester on Sep 28th 2018, flight control problems
An Expressjet Embraer ERJ-145 on behalf of United, registration N14905 performing flight XE-4104/UA-4104 from Chicago O'Hare,IL (USA) to Ottawa,ON…
Newest articles
KLM B739 at Munich on May 9th 2024, flaps problem on landing
A KLM Boeing 737-900, registration PH-BXT performing flight KL-1859 from Amsterdam (Netherlands) to Munich (Germany), was on final approach to…
Lufthansa B748 over Atlantik on May 9th 2024, electrical odour on board
A Lufthansa Boeing 747-8, registration D-ABYP performing flight LH-430 from Frankfurt/Main (Germany) to Chicago O'Hare,IL (USA) with 320 passengers…
Subscribe today
Are you researching aviation incidents? Get access to AeroInside Insights, unlimited read access and receive the daily newsletter.
Pick your plan and subscribePartner
A new way to document and demonstrate airworthiness compliance and aircraft value. Find out more.
ELITE Simulation Solutions is a leading global provider of Flight Simulation Training Devices, IFR training software as well as flight controls and related services. Find out more.
Your regulation partner, specialists in aviation safety and compliance; providing training, auditing, and consultancy services. Find out more.
AeroInside Blog
Popular aircraft
Airbus A320Boeing 737-800
Boeing 737-800 MAX
Popular airlines
American AirlinesUnited
Delta
Air Canada
Lufthansa
British Airways